Poulan 184433 Manual do Utilizador

MODEL NO. POGT20T48STA20.0 HP 48 InchLawn TractorFor Parts and Service, contact our authorized distributor: call 1-800-849-1297For Technical Assistanc

10These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean-ing.DANGER, KEEP HANDSAND FEET

1102734OPERATIONKNOW YOUR TRACTORREAD THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR. Compare the illustrations with your tra

12OPERATIONFIG. 7TO USE CHOKE CONTROL (See Fig. 7)Use choke control whenever you are starting a cold engine. Do not use to start a warm engine.•

13OPERATIONDE FLEC TOR SHIELDFIG. 9FIG. 8PUSH IN TO "DISENGAGE"ATTACHEMNT CLUTCH SWITCH PULL OUT TO "ENGAGE"LIFT LEVER HIGHEST POS

14OPERATIONBEFORE STARTING THE ENGINECHECK ENGINE OIL LEVEL• The engine in your tractor has been shipped, from the factory, already fi lled with

15OPERATIONFIG. 10MOWING TIPS• Mower should be properly leveled for best mowing per-formance. See “TO LEVEL MOWER HOUSING” in the Service and Ad

16BEFORE EACH USETRACT0RInspect Muffler/Spark ArresterLubrication ChartCheck Brake OperationClean Air FilterChange Engine Oil (with oil filter)Replace

17MAINTENANCETRACTORAlways observe safety rules when performing any main- te nance.BRAKE OPERATIONIf tractor requires more than six (6) feet stopping

18MAINTENANCECLEAN AIR SCREENAir screen must be kept free of dirt and chaff to prevent engine dam age from overheating. Clean with a wire brush or co

19MAINTENANCEMUFFLER Inspect and replace corroded muffl er and spark arrester (if equipped) as it could create a fi re hazard and/or dam-age.SPARK PLU

2I. GENERAL OPERATION • Read, understand, and follow all instructions in the manual and on the machine before starting.• Only allow responsib

20WARNING: TO AVOID SE RI OUS IN JU RY, BEFORE PERFORMING ANY SERVICE OR ADJUST-MENTS:• Depress clutch/brake pedal fully and set parking brake.• Pl

21SERVICE AND ADJUSTMENTSFIG. 19FIG. 18BOTTOM EDGE OF MOW ER TO GROUNDFIG. 17BOTTOM EDGE OF MOW ER TO GROUNDAAGROUND LINEFRONT-TO-BACK ADJUSTMENT (See

22SERVICE AND ADJUSTMENTSFIG. 21TO REPLACE MOWER BLADE (SEC OND ARY) DRIVE BELT (See Fig. 22)Park the tractor on level surface. En gage parking brake

23SERVICE AND ADJUSTMENTSFIG. 23FIG. 24FIG. 251-1/2"JAM NUTWITH PARKING BRAKE “ENGAGED”OPERATING ARMNUT “A”STATIONARYIDLERTRANSAXLEPULLEYELECTRIC

24TO START ENGINE WITH A WEAK BAT TERY (See Fig. 27) WARNING: Lead-acid batteries gen- er ate ex plo sive gases. Keep sparks, fl ame and smoking ma

25SERVICE AND ADJUSTMENTSHEADLIGHTWIRECONNECTORFIG. 29HOODTO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 29)• Raise hood.• Unsnap headlight wir

26STORAGEImmediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more.WARNING: Never

27TROUBLESHOOTING POINTSWill not start 1. Out of fuel.

28TROUBLESHOOTING POINTSEngine continues to run 1. Faulty operator-safety presence control system. 1. Check wiring, switches

29BATTERYFUSEIGNITIONSWITCHREDREDREDBLACKIGNITIONUNITNON-REMOVABLECONNECTIONSREMOVABLECONNECTIONSBLACKWHITEREDBLACKSTARTERMCLUTCH / BRAKE(PEDAL UP)SOL

3WARNING: In order to prevent ac- ci den tal starting when setting up, trans port ing, ad just ing or making re-pairs, al ways dis con nect spark pl

30REPAIR PARTSTRACTOR - MODEL NUMBER POGT20T48STA, PRODUCT NO. 954 56 96-77ELECTRICAL2829264033305022792181D.C. AMPERES4512121110821275552162442432541

31KEY PART NO. NO. DESCRIPTION1 144927 Battery 2 74760412 Bolt Hex Hd 1/4-20 UNC X 3/48 7603J Tray, Batte

32REPAIR PARTSTRACTOR - MODEL NUMBER POGT20T48STA, PRODUCT NO. 954 56 96-77CHASSIS AND ENCLOSURES64209158915715617291611662091120920920592816616620913

33NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm1 174619 Chassis 2 176554 Drawbar3

34REPAIR PARTSTRACTOR - MODEL NUMBER POGT20T48STA, PRODUCT NO. 954 56 96-77DRIVE2928895790741357677125192624253353437363562365577222726513011011011151

35KEY PARTNO. NO. DESCRIPTIONKEY PART NO. NO. DESCRIPTIONNOTE: All component dimensio

36REPAIR PARTSTRACTOR - MODEL NUMBER POGT20T48STA, PRODUCT NO. 954 56 96-77STEERING ASSEMBLY3812391373637595779434364381040401186946468692474768151515

37KEY PART NO. NO. DESCRIPTIONNOTE: All component dimensions given in U.S. inches.1 inch = 25.4 mm.REPAIR PAR

38REPAIR PARTSTRACTOR - MODEL NUMBER POGT20T48STA, PRODUCT NO. 954 56 96-77ENGINE21OPTIONAL EQUIPMENTSpark Arrester29262542345810657213143810516105381

39KEY PART NO. NO. DESCRIPTION1 176635X428 Control Throttle2 171875 Screw Hwhd Hi-Lo #13-16 x 3/43 - - - -

4PRODUCT SPECIFICATIONSGASOLINE CAPACITY 5.0 GALLONSAND TYPE: UNLEADED REGULAROIL TYPE (API-SF-SJ): SAE 3

40KEY PART NO. NO. DESCRIPTIONKEY PART NO. NO. DESCRIPTION1 140117

4110379KEY PART NO. NO. DESCRIPTIONKEY PART NO. NO. DESCRIPTION1 59192 C

42REPAIR PARTSTRACTOR - MODEL NUMBER POGT20T48STA, PRODUCT NO. 954 56 96-77MOWER LIFT45623165471817161554541312111313315332321352494951511313208lift-r

431 159461 Wire Asm Inner/Sprg W/plunger2 159476 Shaft Asm Lift RH w/Inf 3 138284 Pin Groove4 12000002 E Ring #5133-625 19211621 Washer 21/32

44REPAIR PARTSTRACTOR - MODEL NUMBER POGT20T48STA, PRODUCT NO. 954 56 96-77MOWER DECK57561181161195117464533464533303032212018213136494936361313713043

45KEY PART NO. NO. DESCRIPTIONKEY PART NO. NO. DESCRIPTIONNOTE: All

46LIMITED WARRANTYThe Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi-als an

4715 DEGREES MAX.FOLD ALONG DOTTED LINETHIS IS A 15 DEGREE SLOPEONLY RIDE UP AND DOWN HILL,NOT ACROSS HILLSUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE

5UNASSEMBLED PARTSSteering WheelSeat(2) KeysSlope SheetKeysSteering Wheel InsertGauge WheelSteering Wheel AdapterSteering SleeveSteering SleeveExtensi

6ASSEMBLYFIG. 1HOW TO SET UP YOUR TRACTORCHECK BATTERY (See Fig. 2)• Lift hood to raised position.• If this battery is put into service after

7ASSEMBLYFIG. 3SEAT PANSHOULDER BOLTADJUSTMENT KNOBFLAT WASHERSEATINSTALL SEAT (See Fig. 3)Adjust seat before tightening adjustment knob.• Remove

8ASSEMBLYFIG. 4SHOULDER BOLTGAUGE WHEEL3/8-16 CENTER LOCKNUT3/8 WASH ERAD JUST ING BARPINRETAINER SPRINGANTI-SWAYBARSINGLELOOP RETAINER SPRINGSGAUGE W

9CHECK TIRE PRESSUREThe tires on your tractor were overinfl ated at the factory for shipping purposes. Correct tire pressure is important for best cut